The Effect of Vibration Frequency on the Physical and Mechanical Properties of the Material and the Phase Structure of the Pump Part

The article solves the scientific and technical problem of studying the effect of vibration loads on the phase structure of the material and the durability of a centrifugal pump. It was found that the natural frequencies of the impeller (>100 Hz) are 75% higher than the operating speed of the str...

Full description

Bibliographic Details
Published in:	Archives of Metallurgy and Materials
Main Authors:	O.V. Ivanova, V.V. Savinkin, A.K. Tuleshov, A.V. Sandu, P. Vizureanu
Format:	Article
Language:	English
Published:	Polish Academy of Sciences 2025-09-01
Subjects:	vibration frequencies phase structure centrifugal pump modeling physical and mechanical properties durability
Online Access:	https://journals.pan.pl/Content/136848/AMM-2025-3-43-Savinkin.pdf

Similar Items

Ensuring vibration characteristics of reactor plant centrifugal pumping equipment
by: D. V. Savchuk, et al.
Published: (2023-05-01)

ON THE DURABILITY OF CENTRIFUGAL PUMPS
by: Marius STAN
Published: (2018-05-01)

CFD-Rotordynamics Sequential Coupling Simulation Approach for the Flow-Induced Vibration of Rotor System in Centrifugal Pump
by: Hehui Zhang, et al.
Published: (2020-02-01)

Design and validation of low-noise centrifugal pumps for marine applications
by: Dazhuan WU, et al.
Published: (2025-10-01)

Selection Strategy of Vibration Feature Target under Centrifugal Pumps Cavitation
by: Ruijia Cao, et al.
Published: (2020-11-01)

Research on the Single-Value Indicators for Centrifugal Pump Based on Vibration Signals
by: Yin Luo, et al.
Published: (2020-06-01)

Investigation on the Vibration Induced by the Rotary-Shaft-Seal Condition in a Centrifugal Pump
by: Jiamin Zou, et al.
Published: (2025-09-01)

Vibration Analysis of a Centrifugal Pump with Healthy and Defective Impellers and Fault Detection Using Multi-Layer Perceptron
by: Masoud Hatami Garousi, et al.
Published: (2024-10-01)

Experimental Comparative Investigations to Evaluate Cavitation Conditions within a Centrifugal Pump Based on Vibration and Acoustic Analyses Techniques
by: Ahmed Ramadhan AL-OBAIDI
Published: (2020-07-01)

Vibrations Detection in Industrial Pumps Based on Spectral Analysis to Increase Their Efficiency
by: Rachid Belhadef, et al.
Published: (2016-03-01)

VIBRATIONS DETECTION IN INDUSTRIAL PUMPS BASED ON SPECTRAL ANALYSIS TO INCREASE THEIR EFFICIENCY
by: Belhadef RACHID, et al.
Published: (2016-01-01)

Study on Vibration Characteristics of Marine Centrifugal Pump Unit Excited by Different Excitation Sources
by: Cui Dai, et al.
Published: (2021-03-01)

INCREASING CENTRIFUGAL PUMP PERFORMANCE
by: S. V. Mikhaylova, et al.
Published: (2019-08-01)

The impact of the multi-gap seals on rotor dynamics
by: V. A. Martsynkovskyy, et al.
Published: (2017-06-01)

Experimental Study and Optimization of the Impeller in High-speed Centrifugal Pump
by: WANG Yanwei, et al.
Published: (2023-08-01)

Analysis and research on vibration characteristics of nuclear centrifugal pumps at low flow rates
by: Xiaohui Luo, et al.
Published: (2022-07-01)

A Review of Fluid-Induced Excitations in Centrifugal Pumps
by: Chengshuo Wu, et al.
Published: (2023-02-01)

MODERNIZATION OF THE FLOW SECTION OF THE MAIN CIRCULATION PUMP GCN 22600-87
by: E. A. Ivanov, et al.
Published: (2018-09-01)

Coupled Vibration of Unshrouded Centrifugal Compressor Impellers. Part II: Computation of Vibration Behavior
by: Dirk Hagelstein, et al.
Published: (2000-01-01)

Research on Centrifugal Pump Speed Measurement Based on Vibration Measurement
by: Yin Luo, et al.
Published: (2025-05-01)

A Technique for Centrifugal Pump Fault Detection and Identification Based on a Novel Fault-Specific Mann–Whitney Test
by: Zahoor Ahmad, et al.
Published: (2023-11-01)

Influence of Dynamic and Static Interference on the Internal Flow and Vibration and Noise Characteristics of Marine Centrifugal Pump
by: Z. Cheng, et al.
Published: (2023-07-01)

Coupled Vibration of Unshrouded Centrifugal Compressor Impellers. Part I: Experimental Investigation
by: Heinrich Hasemann, et al.
Published: (2000-01-01)

Off-Design Operation and Cavitation Detection in Centrifugal Pumps Using Vibration and Motor Stator Current Analyses
by: Yuejiang Han, et al.
Published: (2024-05-01)

A Critical Analysis of Design for Reduction in Vibrations of Centrifugal Impellers
by: Muhammad Umair Najeem, et al.
Published: (2024-07-01)

Optimal Design of a Liquid Hydrogen Centrifugal Pump Impeller
by: Catur Harsito, et al.
Published: (2024-12-01)

Numerical investigation of flow characteristics in the front and rear chambers of centrifugal pump and pump as turbine
by: Yu-Liang Zhang, et al.
Published: (2024-05-01)

Determination of the influence of hydraulic load of centrifugal pump on coordinates of asynchronous frequency-controlled electric drive
by: O. A. Lysenko
Published: (2023-09-01)

Comparative analysis of work of centrifugal and by volume pumps
by: V. V. Kulikov
Published: (2015-08-01)

Modern extracorporeal circulatory support systems (centrifugal pumps and oxygenators). Literature review
by: O. Yu. Esipova, et al.
Published: (2025-01-01)

An Introduction to Sizing Centrifugal Pumps in Aquaculture
by: Jordan Neff, et al.
Published: (2022-11-01)

The CFD simulation of the flow structure in the sewage pump
by: Oleksandr Moloshnyi, et al.
Published: (2018-10-01)

Theoretical Study to Choose The Appropriate Pumps To Solve The Problem of Low Water Levels of The Iraqi Rivers With The Design of A Floating Pumping Station
Published: (2020-12-01)

FORECASTING OF DURABILITY OF ASPHALT PAVEMENT ON THE BASIS OF LEVELS OF THEIR VIBRATION LOADING
by: V. A. Osinovskaya
Published: (2015-12-01)

State of the Art on Two-Phase Non-Miscible Liquid/Gas Flow Transport Analysis in Radial Centrifugal Pumps Part B: Review of Experimental Investigations
by: Michael Mansour, et al.
Published: (2023-10-01)

Experimental Investigation on Velocity Fluctuation in a Vaned Diffuser Centrifugal Pump Measured by Laser Doppler Anemometry
by: Ning Zhang, et al.
Published: (2023-04-01)

Analysis of Cavitation-induced Vibration Characteristics of a Vortex Pump Based on Adaptive Optimal Kernel Time-frequency Representation
by: Y. Wang, et al.
Published: (2024-01-01)

Status Recognition of Marine Centrifugal Pumps Based on a Stacked Sparse Auto-Encoder
by: Yi He, et al.
Published: (2024-02-01)

Modelling the Modes of System of Asynchronous Centrifugal Units of Multi-Unit Pumping Station with Serial Connection of Pumps
by: Vladyslav Lysiak, et al.
Published: (2022-07-01)

Development of an extracorporeal pump for ECMO systems
by: A. P. Kuleshov, et al.
Published: (2025-01-01)